You are using an out of date browser. It may not display this or other websites correctly.
You should upgrade or use an alternative browser.
You should upgrade or use an alternative browser.
Search results
-
J
Help! P0172, p0301, p0302, p0303, p0430, p2196
Needing some advice: CEL is still on with code P0430 which is bank 2. Engine runs fine and normal. However, I smell a ton of exhaust. It smells like when you're behind an old classic car with a carburetor or an older vehicle - that unburnt fuel smell. I can smell it when the windows are...- jeepfix
- Post #11
- Forum: 2nd Gen - 2003 - 2006
-
J
Help! P0172, p0301, p0302, p0303, p0430, p2196
Update: Still running great. New battery this weekend and no problems. CEL is back on but it code P0430 = bank 2 catalyst system efficiency below threshold. I can hear pieces of the cat rattling around when I punch the gas and a few pieces have even fallen out the tail pipe driving down the...- jeepfix
- Post #8
- Forum: 2nd Gen - 2003 - 2006
-
J
Help! P0172, p0301, p0302, p0303, p0430, p2196
Update and hopeful conclusion: Replaced the #1 spark plug. It was only a month old and actually had crud all over it. I also charged the expy battery off my wife's car. Then started the Expy with my wife's car battery still jumper-cabled to it. Cranked a little but fired and went to a...- jeepfix
- Post #6
- Forum: 2nd Gen - 2003 - 2006
-
J
Help! P0172, p0301, p0302, p0303, p0430, p2196
Amazing! Thank you for the link Msport. I pulled the bank 1 fuel rail last night and turned the key to prime the fuel pump. #1 was pouring fuel out. replaced #1 last night along with new oil and filter. Could not get plug out with my small tool set even tough #1 is only a month old from...- jeepfix
- Post #4
- Forum: 2nd Gen - 2003 - 2006
-
J
Help! P0172, p0301, p0302, p0303, p0430, p2196
05 Ford Expedition EB 129,000 miles 5.4 L Dealer and I believe it's a stuck fuel injector on either #1, #2, and/or #3. They said you have to pull the intake manifold to determine though. Expy's sitting in my garage. Anyone ever pull the fuel rail on the bank 1 side? Please PM me your...- jeepfix
- Thread
- Replies: 10
- Forum: 2nd Gen - 2003 - 2006
-
J
Hard starting occasionally when warm plus other codes, 2005 5.4L 3V
Update 8/5/13: Hard starting issue progressively has gotten better. I've done nothing either. One instance last week where it stumbled when engine was warm and seemed to idle rough but didn't last long. CEL came back on and stayed on for about 7 days but never ran the codes. CEL just went...- jeepfix
- Post #4
- Forum: 2nd Gen - 2003 - 2006
-
J
Hard starting occasionally when warm plus other codes, 2005 5.4L 3V
2005 Expedition 5.4 3V 126K miles 3 of 4 new O2 sensors replaced at ~100K Fuel injector #8 stuck and replaced by Ford extended service at ~100K New plugs at 105K Only mod is K&N filter at ~105K History that might help in figuring out my issue: After fuel injector replaced and plugs...- jeepfix
- Thread
- Replies: 4
- Forum: 2nd Gen - 2003 - 2006
-
J
Popping and clicking noise in front end
Just took the car to the dealer, and after a $100 diagnostic fee, they could not find what is causing the noises. They checked all the usual culprits, looked over the 4x4 system, suspension, drivetrain and fluids. They put it up on the rack and drove it. Plus, the drove it in the parking lot...- jeepfix
- Post #4
- Forum: 2nd Gen - 2003 - 2006
-
J
Popping and clicking noise in front end
I get the clunk/pop when hitting bumps now so I checked them and they seem tight with no boot wear. I purchased the Ford Service manual CD and was reading through it last night under the 4x4 section. They had some troubleshooting ideas, so I decided to jack it completely off the ground and...- jeepfix
- Post #3
- Forum: 2nd Gen - 2003 - 2006
-
J
Popping and clicking noise in front end
05 Expedition EB 4x4 109,000 miles Alway drive in 2WD mode We are second owner and have owned the car since 7/11 when we purchased it with 91K miles on it. Popping and clicking started around 96K miles. Noise is coming from the drivers side it seems. First started after allowing it to...- jeepfix
- Thread
- Replies: 6
- Forum: 2nd Gen - 2003 - 2006
-
J
Front end noise - popping sound
Update: the issue has gotten much worse sounding. Now pops and clicks backing up, pulling forward, turning the wheel and not turning the wheel. Plus 4x4 mode now makes no difference. I ordered a service CD and think it's the cv joint on drivers side. Will update later with more news.- jeepfix
- Post #3
- Forum: 2nd Gen - 2003 - 2006
-
J
Front end noise - popping sound
05 5.4 3V 4x4 105,000 miles no prior history of issues I've been searching this site and the f150 sites with no luck. The noise has progressivly gotten worse since 8-2011. Car is in 2wd mode, when the car has been parked either overnight or for a few minutes and when first backing up a...- jeepfix
- Thread
- Replies: 2
- Forum: 2nd Gen - 2003 - 2006
-
J
No power/ idle's rough, runs terrible, HELP
Check out my post under the f150 forum. Look under jeepfix. If while its running rough and you have an excessive fuel smell, its most likely a stuck fuel injector. We have an 05 expedition with 100k. Ford has an extended service call on this covering 100% of cost.- jeepfix
- Post #7
- Forum: 2nd Gen - 2003 - 2006
-
J
05 EB Steering Wheel Audio & HVAC System Control Issues
I just purchased a used 2005 EB. Yesterday and when we bought it two weeks ago, the steering wheel controls worked. I've used the stereo volume, fan and temperature buttons on the wheel and they worked great. This morning, I tried to use them and the + volume changes the band, the -...- jeepfix
- Thread
- Replies: 1
- Forum: Audio & Electronics