Recent content by 2WheelWillie
-
2
2015 turbo whistle noise, and revs hesitation/drops - looses power. no codes
I will add, this was at 168,000-ish miles, The timing chain tensioner was extended fully (no adjustments left), I also paid to have them replace the timing chain, cam phasers (with updated design) while there were addressing a warranty covered timing/water pump cover that was leaking oil. I...- 2WheelWillie
- Post #5
- Forum: 3rd Gen Ford Expedition Engine & Performance
-
2
2015 turbo whistle noise, and revs hesitation/drops - looses power. no codes
‘17 here. Had whistling noise, found out some of the exhaust manifold bolts were rusted and broken. Similar to the issue with the 5.4 issue with bolts rusting and breaking, except on these (3.5 ecoboost) oem manifolds do not use all of the bolt holes available on the heads. WTH Ford! I...- 2WheelWillie
- Post #4
- Forum: 3rd Gen Ford Expedition Engine & Performance
-
2
Sync Bluetooth Audio & Rear Media Console Issues
When did this issue start? Did audio ever work from your phone over Bluetooth? Audio streaming uses a different protocol/mechanism then phone calls in the sync module. Maybe check grounds and connectors at the rear console controls and at the sync module. (2017 XLX) the sync module is under...- 2WheelWillie
- Post #2
- Forum: 3rd Gen Ford Expedition Audio & Electronics
-
2
Front differential rebuild, spider gears are binding
How many miles do you have on the diff? I wonder, if the output bearings are starting to fail do to delaminstion, it is possible other bearings and surfaces are also compromised, out of tolerance. Which bearings did you change? I just replaced my front diff. 2017 XLT with 188,000 miles. Used...- 2WheelWillie
- Post #2
- Forum: 3rd Gen Ford Expedition Transmission & Drivetrain
-
2
2009 Expedition EL - Crank No start. Fuel pump?
FosterMD, I’ve never heard of that, but wouldn’t that condition prevent the vehicle from starting at any temp if the vehicle sat at ambient temperature for more 6 hours? If is 24 degrees outside Ike today or 105 in the summer. Oil and coolant will be at the same temp or in the 10 to 15 degrees...- 2WheelWillie
- Post #5
- Forum: 3rd Gen Ford Expedition General Discussion
-
2
2009 Expedition EL - Crank No start. Fuel pump?
I had an 2009 F150 with 5.4. Had same issue. Ford had a TSB and a kit to relocate the fuel pump fuse to an unused location in the main power distribution fuse/relay box on top of the radiator.- 2WheelWillie
- Post #3
- Forum: 3rd Gen Ford Expedition General Discussion
-
2
Pre wired Plug for trailer brake controller
Did you sort this out?- 2WheelWillie
- Post #3
- Forum: 3rd Gen Ford Expedition Electrical
-
2
Chewed through 3 Turbos in less than a month
i have a ‘17 XLT bought with 164K on the clock. Shortly after purchase I started to get a pitched screeching sound under heavy acceleration. It sounded like the passenger turbo was metal on metal. It was determined the passenger side exhaust manifold was leaking. Ford did not use all of the...- 2WheelWillie
- Post #6
- Forum: 3rd Gen Ford Expedition General Discussion
-
2
Unwise to buy a 2017 Exp XLT with 140K?
Hello GreenRoomSon, Last Nov. 2023 I purchased a 17 XLT with 164K. I purchased from a used car dealer and I did buy the offered extended warranty (24K miles/24 months). I did a fair amount of research on the 3.5 Eco, have been a lurker for a long time. Coming from an 09 F150 SuperCrew with...- 2WheelWillie
- Post #7
- Forum: 3rd Gen Ford Expedition General Discussion
-
2
Oil leak?
Looks like the motor mount to me, but I doubt it is leaking. Usually the are made or hard rubber. Ford calls them: Insulator Assy - Engine Support Insulator Picture is disorienting. Is that on the driver side? Looks like oil is leaking from the sensor or oil filter adapter and blowing back...- 2WheelWillie
- Post #2
- Forum: 2nd Gen Ford Expedition General Discussion
