Search results

  1. K

    2004 replacement ABS speed sensor

    I'll be looking into those - thanks for the link. What kind of prep is involved with the slip ons?
  2. K

    2004 replacement ABS speed sensor

    Yep - rusting away. Typical Minnesota Expy. With 180k miles on it, i'm not sure it's worth the $$$ to have them replaced.
  3. K

    2004 replacement ABS speed sensor

    The stance of the Expy in your profile pic is awesome (I'm assuming it's yours)!!! I'd try to copy it if I still had rocker panels.
  4. K

    2004 replacement ABS speed sensor

    The stance of the Expy in your profile pic is awesome (I'm assuming it's yours)!!! I'd try to copy it if I still had rocker panels.
  5. K

    2004 replacement ABS speed sensor

    I went with the 3-year NAPA hub. Finally found the connector after removing the inner fender liner and feeling around on the bottom of the inner fender.
  6. K

    2004 replacement ABS speed sensor

    I ended up replacing the hub. Got everything installed, but spent the last couple hours hunting for the harness connection for the abs sensor, but can't find it. Does this thing tend to go into hiding?
  7. K

    2004 replacement ABS speed sensor

    I purchased it locally. Unfortunately it can't be returned because my son-in-law used a hammer and screwdriver to 'convince' the sensor to fit. I'd normally do the work, but injured my thumb and am benched for awhile. I'll use the VIN on a search to see if it mkkes a difference.
  8. K

    2004 replacement ABS speed sensor

    I pulled the ABS code
  9. K

    2004 replacement ABS speed sensor

    I forgot to add that the sensor bottoms out on the ring inside the hub and can't be tightened down. I also verified the part number earlier today.
  10. K

    2004 replacement ABS speed sensor

    I'm replacing the LF abs sensor on my '04 XLT. It turns out that the pickup on the old sensor is completely different from the new one - the old one is a cylinder, the new one is about 1/4" longer and rectangular. The cable length and rubber retention points are the same on both old and new...
  11. K

    Front HVAC temp

    Thanks for the info!! Can anybody tell me if there's a semi-easy way to see the actuator and blend door without dismantling the dash (flashlight and mirror)?
  12. K

    Front HVAC temp

    I have an 04 XLT with manual climate control. Adjusting the temp control has no effect on the air temp out of the vents with or without the a/c engaged. Using the Max a/c setting does put out cold air. I don't hear any noises under the dash when adjusting the temp control. Based on what...
  13. K

    rack and pinion issue

    Have you checked inner and outer tie rod ends on that side?
  14. K

    2004 rear different cover removal

    Thanks for the info. It doesn't sound too bad to do - I'll get started when the garage floor warms up a bit.
  15. K

    2004 rear different cover removal

    My 04 Expy has a slow leak from the rear diff cover gasket, and I'm finally getting around to doing the repair. Searches haven't given me any info on what's involved in removing the cover. Could somebody give me an idea of how much of a headache I'm in for ? Thanks
  16. K

    2003 Expedition Rear Differential Cover, 4X4

    I need to replace the diff cover gasket on my 04. Any chance you've done the work on yours yet, and if so, would you share any info on how bad it was to do?
  17. K

    New from Minnesota

    Welcome from Oakdale, MN
  18. K

    2004 Expy diff cover removal

    My 04 Expy has a slow leak from the diff cover gasket, and I'm finally getting around to doing the repair. Searches haven't given me any info on what's involved in removing the cover. Could somebody give me an idea of what's involved? Thanks
  19. K

    Rumbling and vibration when turning right

    Thanks for the replies, and my apologies for my delayed response, EU. There's no binding in a tight turn, so I'll pull the hub(s) once I get the go ahead from my surgeon (*&^# neck surgery).
  20. K

    Rumbling and vibration when turning right

    My 2004 Expy makes a rumbling noise and vibration when turning to the right. This starts as soon as the wheel is moved to the right of center (ie: making a steering correction to the right), and continues from there. It seems to be coming from the left front corner. The noise and vibration...
  21. K

    Whining sound during acceleration

    Serpentine belt tensioner?
  22. K

    Wheel/Tire question.

    I'm surprised it ran at all with a 1" plug gap...:D
  23. K

    Newb from Minnesota

    Great site you have here. Spent some time lurking, decided it was time to join in on the fun. I'm in the process of buying a 2004 Expy XLT from my dad. Has the 5.4 engine, 4wd, currently has 74,000 miles on it, and has been absolutely babied since the day he bought it new. Looking...

Latest posts

Staff online

Members online

Total: 2,476 (members: 22, guests: 2,454)

Forum statistics

Threads
57,014
Posts
535,889
Members
54,710
Latest member
Smile2013

Share this page

Top