Recent content by rburch
-
Spark plug change... my wallet hurts
I had great success with seafoam. Changed mine at 133,000 (hadnt been changed before!) ran a can of seafoam in the gas and crankcase (helps clean the vct solenoid) And another can i kept running it through the brake booster per directions till it was gone. I think i ended up doing that 4 times...- rburch
- Post #21
- Forum: 2nd Gen - 2003 - 2006
-
-
blend door actuator or blend door?
If its off its because some teeth broke off the gears and there is no fixing that. Have to get a new actuator. 35 bucks at the parts store. Had this problem with the rear vent/floor actuator on my 05. Just made it open to the vents and unplugged it!- rburch
- Post #4
- Forum: 3rd Gen - 2007 - 2017
-
-
-
2004 Rear wiper motor needed?
Are you sure its the motor? 2nd gens have an issue where the metal for the wiper stud and the housing corrodes and gets dirty keeping the wiper arm from moving. I had the same issue with my 05. Took it apart, cleaned and greased it and its worked fine ever since! An easy way to check is to...- rburch
- Post #4
- Forum: 2nd Gen - 2003 - 2006
-
Old member checkin.... again.....
Well i have put like 25,000 mile on the Expy and havent had any big problems! Had a miss and got all 8 coils covered under warranty because a new kid messed up! Should have been covered cause its electrical. Had all 8 plugs replaced about 135,000, before i took it in i gave it the seafoam...- rburch
- Post #6
- Forum: General Discussion
-
Old member checkin.... again.....
Well been away for some time dealing with LIFE! Sometimes i wish i was old enough to retire! Still working (thank god!) But i comes with a lot of hours! Got to missing all the great people and knowledge here so ill stop in from time to time!- rburch
- Thread
- Replies: 6
- Forum: General Discussion
-
-
-
2012 Rear Window Leak
I have an 05 and I have the same problem. I have to clean the seal and window at least once a week.- rburch
- Post #13
- Forum: 3rd Gen - 2007 - 2017
-
-
2012 Rear Window Leak
What about bubbling paint?! Thats the fist major issue people have and i believe the first warranty that runs out! There are several people on here with this issue and millions around the world and its not just limited to Expys! It is clearly a defect in the paint process since it starts from...- rburch
- Post #11
- Forum: 3rd Gen - 2007 - 2017
-
needs more power, what to do...
Charge it! Head spinning amount of knowledge around here on the subject!- rburch
- Post #10
- Forum: General Discussion
-
What did you do to the expy today
Yesterday i shined mine up like a new penny and ran to the parts store and got some rattle cans to paint the bumpers and side panels. I was going to get some new profile and sig pics but figured i paint first. !!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!AND OF COURSE TODAY IT WOULD...- rburch
- Post #481
- Forum: General Discussion
