Search results

  1. J

    98-02 Expedition and Navigator check suspension light diy solve

    This connector is horizontal ABOVE and near the back of the radio. Do you have an extra connector because of some work you did, or just an extra in there? The connector here is usually plugged in. Did you convert from air suspension to springs?
  2. J

    Fuel pump going out?

    I'm pretty sure you can rent/borrow the fuel pressure test kit from the major auto parts stores. Fuel Pump Diagnostic Kit | AutoZone.com I'm interested in this thread too. I have also started experiencing longer cranking time. At 155000 miles it seemed to just take a second or two crank. But...
  3. J

    P0402 - Exhaust Gas Recirculation (EGR) Flow Excessive Detected

    I didn't clear the code when I replaced the DPFE sensor and the CEL went out today, after about 80 miles. YAY!
  4. J

    My 97 Expo makes a single pop sound???

    Speaking of brake calipers. Check for loose or missing caliper bolts? I had both caliper bolts missing from the left rear. When I noticed mine were missing. I saw lots of messages about F-150's losing front caliper bolts.
  5. J

    My 97 Expo makes a single pop sound???

    Ball joint? Jack up the front end. Grab the tire and try to move it around forcefully.
  6. J

    Overheating

    Might try getting more air out of the system. Here's the only decent thread I could find. How to "BURP" your cooling system - Ford Truck Club Forum I think
  7. J

    P0402 - Exhaust Gas Recirculation (EGR) Flow Excessive Detected

    Sold my other car yesterday and got in the Navigator to go home and the check engine light came on. :mad: Went to Oreilly's this morning and had the code read. P0402 Did some internet searching and found most people said it's the DPFE sensor and probably not the EGR valve. I went back...
  8. J

    Coverted Air Suspension to springs and shocks

    Here's a link that will help! http://www.expeditionforum.com/f42/98-02-expedition-navigator-check-suspension-light-diy-solve-15630/
  9. J

    Air Spring to Coil Spring Conversion Kit

    Hey Matt if you have a 1st gen the answer is here: http://www.expeditionforum.com/f42/98-02-expedition-navigator-check-suspension-light-diy-solve-15630/
  10. J

    Navigator wheels installed in my 99 EB

  11. J

    Navigator wheels installed in my 99 EB

    Those really are the best stock wheels. The directional wheels look so dated. The navigator wheels have stood the test of time. I saw a set on Dallas craigslist when I was looking for tires a while back. But, they had crappy tires.
  12. J

    Just bought a 99 EB Expedition

    I would definitely read through this thread and check all the things mentioned. http://www.expeditionforum.com/f27/rough-idle-p0171-p0174-heres-what-you-need-check-first-4926/ Not mentioned in that thread, but a new fuel filter made a world of difference for me.
  13. J

    Power cord hanging out of my front grill

    I'ts gotta be a block heater.... Won't be needing that in Phoenix. Did you run a carfax or autocheck? Has it ever been used up north? Here's a site you can plug in your vin and it will give you free autocheck: http://geniusv.in/
  14. J

    Lean Codes

    This could be a fuel delivery problem too. I had P0171(with no drive-ability problems)and replacing the fuel filter cured mine. But it could also be the pump or injectors. You might check the fuel pressure. I'm guessing my filter wasn't clogged enough to cause any problem at low RPM, but when...
  15. J

    Banker with tools vs Cylinder Head

    This is my new favorite thread. I hope you pull this off!
  16. J

    Turn signal issue

    Based on what I see on my commute... Lots of people don't use turn signals anymore! Maybe they changed the law and I didn't hear about it. I wouldn't worry about it if I were you!
  17. J

    Michelin ltx a/t2

    I have the LTX MS2 on another truck. Not the Navigator, they are great tires with long life. I was once told there are 2 kinds of tire. 1. Michelin 2. Mistake
  18. J

    Expy "Owl In The Grill" option...

    Check it out. Sweet! Florida Driver Gets Owl Stuck In Grill <----------Link to the article, with video
  19. J

    Brake Fluid Flush/Change and Missing Rear Caliper Bolts

    Yah...I put some blue thread locker on on them. I saw lots of horror stories about Exploders and rangers losing caliper bolts. Look At this LINK Most bad things I saw online were from FRONT calipers.... I yanked around on the caliper that was missing bolts. Because of the clips on the pad, I...
  20. J

    Crazy vibration at 40 or more front end TCASE

    So...do you think it's loose in the transfer case only? Or maybe the front differential? Or maybe the drive shaft is out of balance? I am pretty sure I have a similar leak on the Navigator transfer case. I was looking at options. I'm not sure I want to pull it out and try to get it resealed...
  21. J

    Brake Fluid Flush/Change and Missing Rear Caliper Bolts

    I had a scare on the highway yesterday....in bumper to bumper traffic... You know the drill....unexpected sudden stop...the pedal is at the floor but the ABS hasn't kicked in. Luckily I had a nice following distance. Went to Oreilly's this morning and got "Dorman Help! - Speed Bleeder Part #...
  22. J

    P0171 Not the PVC elbow. Cleaned MAF.

    Here's an update. I'm not sure it's fixed....but.... I changed the fuel filter Saturday. I had bought it for maintenance but never put it in. New Motorcraft filter. The filter I took out was Motorcraft and I know the previous owner hadn't had it at the dealer in years. Nothing dramatic poured...
  23. J

    P0171 Not the PVC elbow. Cleaned MAF.

    Wouldn't misfile show a code? I was really hoping for another code when I went and got it read.... I forgot to mention that I sprayed carb cleaner around the intake manifold gasket to see if I could get it to affect the idle....but no luck... I have bought plugs and coil boots that I never...
  24. J

    P0171 Not the PVC elbow. Cleaned MAF.

    Hi all, When I got this Navigator it had TERRIBLE IDLE and the CEL was on. The rear suspension was also down. I have done the Monroe conversion and some other suspension work. Since the IDLE was so bad I checked the elbow on the back of the Manifold and it fell apart in my hand. So, I...
  25. J

    Creaking/popping with suspension

    I think you might be surprised to find there are not any grease fitting on the stock parts. Or not many. I can't think of any of the stock suspension parts that had grease fittings. Not the ball joints, tie rod ends, universal joints. None of mine came from the factory with grease fittings...

Latest posts

Members online

Total: 2,230 (members: 17, guests: 2,213)

Forum statistics

Threads
57,014
Posts
535,884
Members
54,708
Latest member
Landsbutter

Share this page

Top