Search results

  1. 6

    Waiting diagrams for mirrors 07 and 03

    I'm working on swapping out the mirrors on my 03 EB with some from an 07 EB. Needed the wiring diagrams for each so I can wire up everything.
  2. 6

    Opinions on trading in 2nd gen for 3rd gen

    I have an '03 expy eb with 5.4 4wd 205k. It currently needs a new ac compressor and seal changed in transfer case to keep transmission fluid from leaking into it. My wife wants a newer one like a 13-14 EL. I know the 5.4 2v has less issues than the 3v. Should I fix the problems on the '03 or...
  3. 6

    Rear sway bar bushing bolts ?

    Finally getting around to installing the belltech sway bar and used impact to loosen the bushing bolts and they just spin. I'm assuming I'll have to cut the nuts off, but can't even get to the top side of the one closest to gas tank. Do I have to drop gas tank to get to it?
  4. 6

    Battery drain

    My battery gets low after 3-4 hours. I haven't had a chance to do a voltage drop test yet but I charged my battery and unhook it after I get to work or home to keep it from going dead. I charged it today to 100 percent. I hooked up battery and drove 40 miles to work then unhooked it. The drive...
  5. 6

    Better gas mileage?

    I'm gonna have to daily the expedition and I drive 400 miles week for work. So far I pulled out the middle seat in 2nd row, removed running boards, and the muffler and tail pipe. Im going to remove the roof rack and the front drive shaft until winter hits. The AC doesn't work, if I bypassed the...
  6. 6

    Rear wiper delete

    I did a rear wiper delete, super easy. Has anyone else done this?
  7. 6

    Rear drive shaft

    I need a new driveshaft in my 03 eb, and was wondering if the '05-'06 drive shaft was the same as '03-'04?
  8. 6

    Awd issue, but 4x4 mode no issue

    I had my expy in awd and after making a turn and going forward for 50-100 ft it feels like I'm going over a rough surface and then it's fine...doesn't do it 4 wheel high but when disengaging 4 hi back to 2wd it seems like I have to stop and back up to get it to disengage. Any ideas?
  9. 6

    F150 seats?

    Do 04-08 f150 front seats bolt into 03-06 expeditions? I hate my front seats.
  10. 6

    Changing forgotten fluids

    My expy has 202k on it and I want to change out the power steering fluid, transfer case, and front and rear axles. I know the power steering takes mercon v and I'm pretty sure the transfer case takes mercon lv. What do I use for the front and rear axles?
  11. 6

    Rear axle issues?

    Does the 2nd gen have rear axle issues? I was driving from home depot and had the back glass open because I was hauling lumber. When I got up to 70 something smelled hot like it was burning. Once I slowed down below 70 I didn't smell it again but I've smelled it other times while driving. I have...
  12. 6

    '03 expy sways back and forth

    I just replaced upper ball joints and strut/shocks and had an alignment done. When I'm driving down back country roads the expedition sways back and forth a lot. Would that be sway bar links front and back or do I need to upgrade factory sway bars?
  13. 6

    Changed map lights to LED

    Changed map lights to LED and now they don't turn on with door open only turn on when I push the light on. Any ideas?
  14. 6

    Bad inner tie rod?

    I jacked up the driver's side of my 03 expedition to check ball joints and tie rods. When I grabbed the tire at 3 and 9 o'clock the wheel moved easily even with passenger tire on the ground and I could see the steering shaft move. I'm assuming that's not normal but not sure. There wasn't any...
  15. 6

    03 Eb mirrors

    I have an 03 Eddie Bauer and the outside mirrors want to move everytime i use the key fob to unlock the doors. Is there a wire I can cut to keep it from moving or can I swap to maybe some xlt mirrors that are heated?
  16. 6

    rear toe links/tie rod end

    I was replacing the rear toe link or rear outer tie rod on my '03 and was wondering if they usually replace the whole thing when replacing the end? If not how do I know when its time to replace the inner part?
  17. 6

    vacuum lines?

    Hi, im new here not getting much help on the other forum I go to so figured l'd try here. A squirrel got under the hood of my expy and chewed up a bunch of vacuum lines and wires. Im starting with the vacuum lines. Theres some egr stuff on the drivers side and I have a red vacuum line and a...

Latest posts

Members online

Total: 980 (members: 13, guests: 967)

Forum statistics

Threads
53,579
Posts
502,146
Members
47,146
Latest member
jcason94

Share this page

Top