2019 EXPY PASSENGER FLOOR CARPET PADDING SOAKED

[harrelljr99]

Did you figured out what caused this?


Sent from my iPhone using Tapatalk

 

[Grey ghost]

I would see if someone can do a smoke test to locate the leak. Could even be a door seal.
Thanks for what you do,! I'm a retired DUSM. myself. Good luck. On your leak.

 

[Shaffer9]

Does the rear washer spray fluid? It might be a leak in the line going to the back.

 

[StealthyBulldog]

Has the windshield been replaced? A previous topic had mentioned it wasn't installed correctly and leaked, although I guess the question should be asked if it is only after a rain or car wash?

 

[harrelljr99]

It sounds like this may be the issue.


https://static.nhtsa.gov/odi/tsbs/2019/MC-10168762-0001.pdf


Sent from my iPhone using Tapatalk

 

[Apollo]

My expy has the exact same issue....i noticed water stain by the pillar and floor is soaked

Dealer is replacing pillar and roof liner along with the carpet of the truck

They mentioned a drain tube is the culprit...dropping off this week to get fixed...crossing my fingers it solves it

 

[lurch]

My expy had the rear washer line blow apart at the firewall. It dumped most of the washer fluid bottle into a the gutter that runs along the passenger interior under the plastic door sill trim bits. The carpet was pretty wet as it wicked the fluid.

 

[Apollo]

My leak is still there and now going back for the third time.

Any update on your expy?

 

[Janky]

Sorry, I didn't see this thread. I just posted a similar issue (https://www.expeditionforum.com/threads/interior-water-leak.45762/)
Curious what you find.

 

[Janky]

@TomF any update?